Maintenance Schedules

• Includes up to 5 L Motorcraft oil
• Includes new Motorcraft filter
• Diesel equipped vehicles extra

• Check power steering fluid
• Check trans. & engine coolant recovery tank fluid levels
• Check brake fluid
• Check tire pressure
• Check washer fluid
• Wiper blade wear
• Inspect air filter
• Battery inspection (visual)
• Exhaust system
• Visual inspection

• Rotate tires every 10.000 km
• Other unique applications may require more frequent tire rotation.

• Inspect friction material, rotors, drums, wheel cylinders, hoses, and connections
• Inspect park brake operation
• Clean & lubricate caliper slide rails (if applicable)

• Power flush fluid

• Lubricate transfer case shift lever pivot bolt and control rod connection pins every 20,000 km
• Replace transfer case fluid every 100,000 km
• Lubricate front axle RH axle shaft slip yoke every 50,000 km
• Inspect and lubricate spindle needle bearings every 50,000 km (if serviceable)
• Inspect and lubricate hub locks every 50,000 km if serviceable.

• Inspect parking brake fluid level every 20,000 km
• Replace rear axle lubricant every 50,000 km (F-450, F-550)
• Replace manual transmission fluid every 100,000 km
• Replace fuel filter every 20,000 km
• Retorque dual rear wheels after 160 km of service, then 800 km later; repeat sequence after any rear wheel removal or tire rotation.

• Inspect and lubricate hub locks.
• Inspect and lubricate automatic transmission, transfer case and clutch linkages.
• Check spring U-bolt locks.
• Check the differential vent hose.
• Check axle fluid for water contamination.
• Repack front wheel bearings and hubs where serviceable.
• Lubricate spindle needle bearings (4x4)
• Brake inspection
• Thoroughly clean underbody as required

• Add FW16 Coolant Conditioner, if equipped with "green" coolant, every 12 months or 20,000 km (whichever occurs first)
• Check air filter minder every 5,000 km replace air filter as required.
• Replace fuel filter every 20,000 km
• Drain water from fuel filter reservoir every fuel fill-up.
• Inspect air filter daily in dusty conditions and replace if necessary.

• Replace brake fluid every two years.

• For NGV and propane vehicles, drain coalescer and replace O-ring seal and fuel filter every 50,000 km
• Inspect NGV fuel tank every 3 years from the date of tank manufacture, at Ford approved gaseous fuel dealers.
• Inspect propane fuel tank every 5 years from the vehicle build date at Ford approved gaseous fuel dealers.
• Replace NGV tanks every 15 years from the date of tank manufacture.

If you primarily operate your vehicles in any of the more demanding "Special Operation Conditions" listed below, perform oil and filter changes every 3 months or 5,000 km and automatic transmission fluid and filter changes every 30 months or 50,000 km if you only occasionally operate your vehicle in these conditions. It is not necessary to perform the additional maintenance.

• You tow a trailer or use a camper or car-top carrier.
• Most trips include extensive idling (such as frequent driving in stop and go traffic)
• You carry heavy loads.
• The vehicle is used for delivery service, police, taxi or other commercial application.
• You operate in dusty conditions such as unpaved or dusty roads.
• You operate the vehicle off-road in water that is deeper than the hubs (1/2 wheel height) or in extremely muddy conditions. Affected components must be serviced daily.

• Engine oil and filter service
• 10 point inspection
$49.95

• Engine oil and filter service
• 10 point inspection
• 23 point inspection (rotate tires)
$89.90

• Major Emission Service [Gas Only]

• Engine oil and filter service
• 10 point inspection
• Align Steering (extra for 4 whl independent susp.)
• Balance 4 wheels
• Clean battery terminals and check electrolyte level on low maintenance batteries
• Inspect engine cooling system, hoses, clamps and check coolant strength
• Inspect fuel lines and hoses for leaks or damage
• Lubricate all hinges, latches and key locks
• Lubricate door rubber weatherstrips
$224.90

• Engine oil and filter service
• 10 point inspection
• 23 point inspection (rotate tires)
• Minor tune - parts additional only if required.
• Replace fuel filter
• Clean battery terminals and check electrolyte level on low maintenance batteries
• Inspect engine cooling system, hoses, clamps and check coolant strength
• Inspect fuel lines and hoses for leaks or damage
• Lubricate all hinges, latches and key locks
• Lubricate door rubber weatherstrips
• Inspect thermactor hoses and clamps
• Align steering (extra for 4 whl independent susp.)
• Balance 4 wheels / rotate tires
• A/Transmission service (if applicable)
• Inspect clutch operation (if applicable)

• Engine oil and filter service
• 10 point inspection
• 23 point inspection (rotate tires)
• Power flush cooling system
$248.85

• Major Emission Flush